Co. Antrim firm and sub-contractor fined after serious incident

Date published: 28 August 2019

A Co. Antrim firm and a sub-contractor have been fined after an electrical contractor had his foot trapped in a hydraulic powered compactor known as a Briquetter.

Following an incident where a self-employed electrical contractor sustained serious injuries at its premises, Enva Toomebridge Limited (formerly known as Clearcircle Environmental (NI) Ltd) was fined £1,500 after pleading guilty at Magherafelt Magistrates Court to Article 5(1) of the Health and Safety at Work (Northern Ireland) Order 1978. Arising out of the same incident Mr Declan Quinn, a self-employed Maintenance Contractor, was fined £500 after pleading guilty to Article 5(2) of the Health and Safety at Work (Northern Ireland) Order 1978.

The guard on the hydraulic ram had been removed by Mr Quinn when he was investigating a potential fault. During a period when Mr Quinn was not present the injured person returned to complete other work. The unguarded ram of the Briquetter machine started automatically and began to crush his left foot causing severe injuries. He was trapped for approximately 45 minutes.

HSENI Inspector Martin Rafferty said: “The investigation found that Mr Quinn and Enva Toomebridge Limited, failed to take appropriate measures to ensure maintenance operations on work equipment were undertaken safely and without risk to others. 

“Many accidents occur during maintenance work. Effective control measures must be taken to prevent access to dangerous parts of machinery. This includes the use of suitable means of isolation to ensure work equipment has been disconnected from all power sources and any residual power removed before work commences. 

“This incident was foreseeable and preventable. Injury could have been avoided if simple control measures had been put in place. Maintenance work must be properly assessed and effective control measures applied to minimise the risk of people coming into contact with dangerous parts of machinery.” 

Further information is available within HSE codes of practice http://www.hse.gov.uk/pubns/priced/l22.pdf and guidance document http://www.hse.gov.uk/pubns/indg229.htm

 

Notes to editors: 

1.         Breaches and fines for Enva Toomebridge Limited are as follows:

            a.   Article 5(1) of the Health and Safety at Work (Northern Ireland)  Order 1978: fine £1,500;

2.         Breaches and fines for Mr Declan Quinn are as follows:

            a.   Article 5(2) of the Health and Safety at Work (Northern Ireland) Order 1978: fine £500;

3.         For media enquiries please contact HSENI Press Office on 028 9024 3249, or email  media@hseni.gov.uk

4.         For Out of Office Hours please contact the Duty Press Officer on 028 9037 8110.

Share this page